Contents: Lubricants, working fluids, sealants…⇩ Filling volume ⇩ General specification ⇩ Tightening torques ⇩
Lubricants, working fluids, sealants and adhesives
| Detail | Specifications |
| Recommended lubricant – 3.2 Petrol * | Esso JWS 3309 US. Land Rover Part Number LR002748 |
| Recommended lubricant - 2.2 diesel engine, vehicles manufactured before 2011 * | Esso JWS 3309 US. Land Rover Part Number LR002748 |
| Recommended lubricant - 2.2 diesel engine, vehicles manufactured after 2011* | Nippon AW-1. Land Rover Part Number LR0022460 |
| Torque converter neck+ | Molykote FB180 |
| Grease for cardan shaft splines | Weicon Anti Seize - 6G92M1C27AA |
| Sealant between the pan and the gearbox | LR002912 |
* Do not use any lubricant other than that specified.
+ Avoid overfilling the lubricant.
Filling volume
| Detail | Volume (liters/pints/US quarts) |
| Initial "dry" filling* | 7,0/12,3/7,4 |
* The final oil level check/topping up must be done with the block installed
General specification
| Detail | Specifications |
| Automatic transmission | Aisin AWF21 (6-speed automatic) |
| Maximum torque: | |
| Petrol 3.2 l | 315 Nm (232 lb-ft) |
| Diesel 2.2 l | 450 Nm (332 lb-ft) |
| Gear ratios: | |
| 1st gear | 4,148:1 |
| 2nd gear | 2,370:1 |
| 3rd gear | 1,556:1 |
| 4th gear | 1,155:1 |
| 5th gear | 0,859:1 |
| 6th gear | 0,686:1 |
| Reverse | 3,394:1 |
| Final drive ratio: | |
| Petrol 3.2 l | 3,750:1 |
| Diesel 2.2 l | 3,329:1 |
| Torque converter: | |
| Petrol 3.2 l | D260 170K |
| Diesel 2.2 l | D260 186K2 |
| Gearbox control module: | |
| Location | Built into the top of the gearbox housing |
| Type – petrol 3.2, cars manufactured from 2007 to 2009 | SH 7055 |
| Type – diesel 2.2, cars manufactured from 2007 to 2010 | SH 7055 |
| Type – petrol 3.2, cars manufactured before 2011 | SH 7058 |
| Type – petrol 3.2 and diesel 2.2, cars manufactured after 2011 | SH 7058 |
Tightening torques
| Description | Nm | lb-ft |
| 3-pin solenoid S1 | 10 | 7 |
| 3-pin solenoid S2 | 10 | 7 |
| Cover Bolt - PTU Side - 2.2L Diesel Engine Only | 24 | 18 |
| Cover Bolt - Starter Side - 2.2L Diesel Engine Only | 24 | 18 |
| Drain plug bolt | 47 | 35 |
| Torx Bolt Filler Plug | 39 | 29 |
| Bolts for fastening the flexible plate to the torque converter | 60 | 44 |
| Gearbox Oil Pan Torx Bolts | 13 | 10 |
| Lock Plate Bolt - Oil Temperature Sensor | 10 | 7 |
| Main Control Valve Block Bolts | 10 | 7 |
| Torx overflow bolt | 7 | 5 |
| Suction side cover - valve assembly | 10 | 7 |
| Transmission Control Module (TCM) Bolts | 24 | 18 |
| Transmission Control Module (TCM) Support Bracket | 25 | 18 |
| RPM sensor - input signal | 5 | 3,7 |
| Gearbox to engine mounting bolts - M10: | ||
| Petrol 3.2 l | 48 | 35 |
| Diesel 2.2 l | 65 | 48 |
| Gearbox to Engine Mounting Bolts - M8 - 3.2L Petrol Engine Only | 24 | 18 |
The original article is located on the website [LRman.ru]
Comments on this article